Visible crew/equipment: Just after the beginning credits end, you can see the reflections of the boom, the crew and other things as they pass the 4x4. (Most visible on VHS version). (00:02:35)
Continuity mistake: In the beginning of the movie Jeff and his wife were moving to San Diego from Massachusetts. Well, they were driving in their new Jeep (with Massachusetts plates) through Arizona. When Amy comments about how fast Jeff is driving, the camera shot shows the speedometer at 80 mph and the odometer shows the Jeep has only 245miles. That must be a new record from MA to AZ..... (Note: not visible on DVD version of film.)
Visible crew/equipment: During the scene where the car breaks down and pulls to a stop in the middle of the road there is a shot of Kurt Russel getting out of the car. Look in the passenger side door, you can make out a camera reflection. Also, look out for the reflection of a reflecting light in the window as Kurt goes to get the cell phone. This is most obvious when the door swings open. (00:08:25)
Revealing mistake: When Kurt is being chased after in the truck at the end, he pulls out onto the main highway and the truck skids. There are several tire marks where they practised this skid before. Also, at the very end when the truck is being pushed by the semi, look ahead of the front truck tire, more previous tire marks. (01:21:20)
Visible crew/equipment: During the confrontation between the bad guy and Kurt at the first gas station (where he leaves his hood open,) the camera and two crew members can be seen in the passenger side window as the camera follows the bad guy walking along the Jeep. Look out for the boom mike reflected in the windshield in the same shot as well. Both are really obvious. (Not visible on DVD version).
Other mistake: At the end of the movie when the truck falls off the bridge and hits the water, the hood breaks off and you can see that there is no engine or transmission in the truck. (01:28:40)
Other mistake: In the bank scene, the monitor on the bank manager's desk goes from being connected and has a power cord, however when Kurt rises to go to the bathroom, the back of the monitor shows no cords whatsoever. (00:48:00)
Revealing mistake: When Jeff and Amy are being chased by Red near the end and Red's truck begins to jackknife, you can see how they made the trailer slide in that direction. It seems that they constructed or used a trailer that had a set of wheels that would turn. They were turned in the direction of the slide.
Other mistake: At the end of the movie, just before the credits, Kurt Russell and Kathleen Quinlan are leaning against the guardrail in each others arms as the camera shot widens. The destroyed truck they were in is against the rail and the roadway is shown. But there are no skid marks on the road surface. Their truck had been pushed sideways at least 50+ feet by the villain's semi tractor and there should have been skid marks from both vehicles.