Deliberate mistake: When Tarzan fights with the leopard, it scratches his chest. However after they fall into the pit and Tarzan comes out carrying the dead leopard, the scratches on his chest have amazingly healed. [It is a long-standing Disney tradition that no evidence of violence is shown on screen. Still a mistake, but there's why].
Deliberate mistake: When the characters are crossing the street to get to the toy store, Mr. Potato Head gets his foot stuck on some gum. From the first angle, the gum is at the half way point of the rolling cement drainage pipe. When he barely escapes, the gum is near the lip of the pipe, a foot or so from the end. As the gum sticks to the passing pipe, it appears to be half way between those two points. (00:38:15)
Deliberate mistake: At the elephant graveyard, little Simba claws Shenzi in the face. When Mufasa saves Simba from the hyenas, the cuts are gone, a few seconds later. [This was done intentionally, I'm sure, for two reasons. The first being, Disney doesn't let fresh scars linger on the screen too long. Secondly, during that same scene when Mufasa rescues Simba & Nala, he claws Banzai in the rear. To stress the point later in the movie, that severe scar is shown too, but only briefly, it too disappears because of reason 1. Still a "mistake", but there's why.] (00:21:50)
Deliberate mistake: Towards the end of the movie fish are seen to swim down in order to submerge the net in which they have been caught. Although the attempt seems logical, it actually needs power against the net to push it down. None of the fish seem to touch the net at the bottom however and if it is the whole mass of fish achieving it, then the bottom fish should have been squashed against the net which (again) isn't the case. 'What brings the net down?' is the question here. (Done deliberately by Disney/Pixar to be visually aesthetically pleasing.)
Deliberate mistake: When Boo laughs repeatedly while playing hide-n-seek with Sully in the men's room, nothing happens to the electricity - no surges as with all other times she laughs. [In the audio commentary by the directors, they explained that it would've been distracting if an energy surge occurred every time Boo laughed, so they simply didn't address the issue. A reasonable course of action, but still a mistake.] (00:37:30)
Deliberate mistake: At the end of the film, Gaston shoots the Beast with an arrow and pushes the Beast out the window. When the Beast lands on the edge of the castle rooftop, the arrow has disappeared. Even if part of the arrow has broken off, a piece of it would still be in his back. [This, like many other incidents in the film, is a longtime Disney animated tradition. The company seems to believe that violence is less unpleasant if all evidence of it disappears quickly. This is why so many cuts seem to disappear or become less serious. The arrow vanishing is just another example.] (01:16:55)
Deliberate mistake: When Alex, Marty, Gloria and Melman are talking together inside the boxes, Alex has three holes in his box allowing light in for him. Melman, Marty and Gloria have that too, but Gloria's box is lying under Alex's and Marty's, so it can't get as much light - but it does.
Deliberate mistake: During the movie, when Mulan is just a girl, you can see that her eyelashes extend beyond her eyes. When she is pretending to be a boy, her eyelashes are short (this makes perfect sense). But when she is in the medical tent her eyelashes are long even though she had no time to put on makeup. This is deliberate though, because without it she would have still looked like a boy, and just pulling her hair down wouldn't make her look any different (since that's how she looked in the pond). So they had to change her eyelashes to make her look more girlish.
Deliberate mistake: During the very last race, Lightning McQueen gets next to the green car, and the reflection of that green car's chrome "C" emblem is seen on Lightning McQueen's hood. However, the C is facing the right way. Since the C is placed on the green car in the correct direction, the reflection on Lighting McQueen should be a mirror image.
Deliberate mistake: You might be wondering where Terry suddenly comes up with Jolly Jack all of the sudden after escaping the lab. In the commentary, they say that the Joker, in his transmission to Terry in the lab, was supposed to be eating out of a candy jar with "Jolly Jack" on it, but couldn't have it due to time constraints.
Deliberate mistake: During the dance number in the Dead Bar, the blue pirate has a sword stuck through him with the handle in the front, later it changes to the back, then to the front again. Seen when the groom falls back and grabs the handle, then picks the pirate up and drops him. (00:19:15 - 00:20:05)StopNGo & Girls